endstream endobj startxref 0 %%E

endstream endobj startxref 0 %%EOF 87 0 obj <>stream I toyed with the idea of getting the canon. Many people buy the portable macerators because they believe they don't involve installation work. If you have difficulty registering an account, logging in or need other account-related assistance, send us a message and well get back to you shortly. Connect the 6 foot, switch assembly to RV waste pump motor wires with, butt connectors (connect the orange motor wire to, the orange switch wire; and the black motor wire to, 2. p`\!V8{ETKO'IPW 5lC?EGYH

Rinse pump and discharge hose. Turn off pump and open gray water valve.

I needed about 25 feet for my rig. Locate this connector in the waste, compartment or adjacent to the 3 inch waste drain, and valves. I wouldn't want to go putting holes in the insulation so what options are there for running the power from? Portable rv waste pump Optionally, alligator clips (with 20 amp, rating) may be installed on the 6 foot power.

Empties most recirculating toilets in less than 2 minutes; empties a typical 30-gallon holding tank in less than 3minutes. Rather than the logistics of running wire and mounting outlets, I opted to make a 12vdc extension cord using 10 gauge speaker wire. Thanks for the replies. IMO- 12ga for anything longer than a few feet from the battery is looking for trouble.

I have a minn kota charging station box and an AGM 85AH for the trolling motor on my jon boat. 5 5 5 5 5 5 5 5 5 5 5 5 d4 r, =0NX -/ @qZHT @r00 PA@H -$QIP @q I have never used the flush system on my macerator. The ON/OFF switch is simply clamp it on (ON), or remove it (OFF). I'd recommend a new circuit for the Flojet macerator pump and definitely at least 12 gauge wire (more if the distance is long). Do you want to change sites? IT WILL NOT HANDLE HARD SOLID OBJECTS, SANITARY NAPKINS OR RAGS.

Is there any way I could wire this so I can plug it into a regular camper outlet? NO, there is not.. Locate a 12 VDC, 20 amp power source and install, the 6 foot power connector-cable; Connect the, orange positive wire to a 20 amp circuit, and the, Black negative wire to a negative circuit or chassis, ground. I just wired-up my Flojet.

Come join the discussion about modifications, travel trailers, 5th wheels, appliances, towing, camping, classifieds, troubleshooting, maintenance, and more! Works great, and allows me to easily switch between my front and rear tanks, and to share with friends if I need too.

Never got around to puting a 20 amp take off in the sewer compartment. EQ;IYxNc5 =u3;8nQD |DZ,Ml|nk9maV81H]*DN@l+C) 2XGX Cobra motor home, mini home and van owners manual. 84 0 obj <>stream use a $5 multi meter to test and make sure it's right power. hbbd``b` $KA $Ab, Q Flojet- Adapter O-Ring Kit, (2 o-rings per Kit), Jabsco- Chopper Plate Kit with Locknut, 2 Blade, Jabsco- Chopper Plate Kit with Locknut, 4 Blade, Jabsco- Nitrile Impeller Kit, with Cover Gasket and/or O-Ring and a Pair of Gaskets for Macerator Pumps.

All Rights Reserved. I can only guess that I can indeed use this for connecting the macerator and i simply buy a round terminal connector, crimp that on the wire, slip it on the (red to black, black to white) terminals? It can pull a lot of current under load (I've seen them pop 20A fuses regularly when pumping long distances or through narrow hoses) and often runs for fairly long periods too. You could run it direct from the battery with its own fuse if that is more convenient than tapping the existing fuse panel. Probably be cheaper to just get a battery although the jump box sounds like the easier way to go. It may not display this or other websites correctly.

I have my roo23ss set on my north georgia mountain property. Rik ('75), Kristi ('77), Lexi ('07), Hannah ('10) & Zach ('11) Crosby - Tonawanda, NY. For a better experience, please enable JavaScript in your browser before proceeding.

It looks like you are coming from Indonesia, but the current site you have selected to visit is United States. hb```f``g`a`pfd@ A&(G# p>P7ss08fC%2f5p(e;0Ma`ni"~ :g#pQaP q@ endstream endobj 55 0 obj <> endobj 56 0 obj <>/Font<>/ProcSet[/PDF/Text/ImageB]/XObject<>>>/Rotate 0/StructParents 0/TrimBox[0 0 612 792]/Type/Page>> endobj 57 0 obj <>stream Copyright20072022PumpVendor.com,LLC, 91010-250A Rinse Adapter (comes with the RV Adapter), 18593-1001Pump Body (comes in Service Kit). I'm thinking it's in case you have two grey tanks and a black tank.

Use an automotive 20 amp fuse for, Triplex diaphragm automatic water system pump (4 pages), quad ii diaphragm automatic water system pump (4 pages), Co2 operated beverage pumpm bracket assembly (4 pages), 2100 series duplex diaphragm design automatic water system pump & shower drain general purpose pump (4 pages), Installation for flow reversal valve (2 pages), N5100 series industrial air driven pump (4 pages), Manual will be automatically added to "My Manuals", Water Pump FLOJET G-57 Series Installation & Operation Instructions, Water Pump FLOJET 4305-144 Instruction Manual, Water Pump FLOJET 3426 series User Manual, Water Pump FLOJET N5000 Series Installation, Operation & Service Instructions, Water Pump FLOJET N5100 Series Installation & Operation, Water Pump FLOJET quad II diaphragm 4125 series User Manual, Water Pump FLOJET N5100-010 Installation & Operation, Water Pump FLOJET R3B21 Series Installation Manual, Water Pump FLOJET BevJet Compact Installation/Operation Instruction Manual. I ran a pair of dedicated wires from the battery, through the enclosed underbelly, to near the waste valves, spliced in a connector to fit the one on the Flo-Jet so I have a connector handy when using the Flo-Jet. I did drill two pilot holes for self tapping screws to fasten down the box. Check out this. it can handle 25 amps in open air NEC table 310-16. I ordered a Flojet portable macerator and I am asking about sources of power. Jabsco- Service Kit for Macerator.

The 18555-series waste pump will macerate and pump all waste and tissue normally found in recreational vehicle waste systems. I just dump as usual and make sure the grey water flushes out the pump.

Install waste/garden hose on discharge port. Enter all the quantities you want, click any Order button to add them all to your cart. Sounds like you're ready to get that poop a'flowin!

Just clamp on the jumper cables when you want to empty and turn the switch on. What kind of jump box do you recommend? JavaScript is disabled. Please try again later. Do not use this link to ask for help with RV-related issues; Ask those questions in one of our forums.

Turn on pump. One question..Do any of you have an insulated underbelly. Xv_ga[n-rN:jytaZ3\K]ge3^?jw69fEt|^\IBZ&i7H-"E6WkV=jFYq^P>P('BhB{26a_eaJ Zjgb\ynL4=7x/C+&3qDvp#9;6v;u\cXkv[;wirgh.\'smJ?j6k!FwF}X_*17O[#'j-uB8X (KM`g}(>)1|#.!az[o$3r!)zBv7'%1,"/'XD-{Vye"2Sd/N:[$WHu]1d>iy 8)XqcD|8.Y F`%bn(7^pu^9n6+AAkzmSTRqv|FR.

If you don't have a manual, I would download one for instructions. Is this the best place to hook this up?

I keep mine portable and have used it numerous times although not regularly.

We use data about you for a number of purposes explained in the links below. The Flojet will draw near 20 amps for several minutes (time and max amps depends on the size of the tank being emptied and the size of the discharge hose).

The Lippert frame on my Outback already had a hole in it. Or maybe you can give others some advice? If that works, great. The pump only includes 6ft of wire.

I made a lead with a Bargman connector to plug into the trailer's 12V. and pump. I recently purchased a Flojet portable waste pump Model 18555-000. Like the other posters, the use of speaker wire had me a little alarmed as these macerators can draw 20 amps or more. Install rinse water hose to on-off valve. What kinda price range are we talking about here? %PDF-1.3 convenient position, twisting clockwise to lock. 2009 Toyota Tundra CrewMax 4x4 - 5.7L iForce V8 - 6-Speed Auto - 4.30:1, ~ Ryan & Family - Full timing in a 301BQ since June 2010, The Fora platform includes forum software by XenForo, VerticalScope Inc., 111 Peter Street, Suite 600, Toronto, Ontario, M5V 2H1, Canada. I actually bought a small 12volt car battery from Walmart and carry that with me. ;3B&YHof0q dX I went the simple route. BD7_3012000@ !

You are using an out of date browser. The pump section is self-priming, permitting the unit to be mounted above the tank in a convenient location.

Works just fine that way. Add an item to your cart to see them all.

ky'oG&"1zD5RG?&\#]'>"&Ljoq*4E#LYXLBx{ rrVy"m=/j7V197'~bp-bob?!cF6s [f%ZbAa$Rki6z FD&)$L^! Good Luck.

2020 Grand Design Solitude 380FL, 42' five-slide 5er. 9. Alligator clips allow me to get power from chassi, house or toad battery. I figure it is a 1) high current draw device that I wouldn't be using at the same time as the PC and 2) the wiring is under the trailer not to far from the waste valve.

By continuing to browse our site you agree to our use of data and cookies. J[M/M3 f% `tttiP >j >j >j >j >j -$pPPPPPPPPPPPPPPPPPPPPL@PPP\i F Qj X6 @F) H YG@$f >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j >j -B -B2 ZM20 Zzd@ 6PPPPPPPPPPPPPj& @@@@@@@@@@@@@@@@@z::t:B [ qG1v. Works fine. endstream endobj 2 0 obj <> endobj 3 0 obj <> endobj 5 0 obj <>>>/Resources<>/ProcSet[/PDF]>>/Subtype/Form/Type/XObject>>stream I just recieved my Floject portable waste pump and want to install it, but am a little unsure of where to pull the power from. Municipal Drinking Water Treatment & Distribution, Municipal Sewage Handling & Waste Treatment, Water & Wastewater Treatment Systems & Solutions, < View all Marine / RV Toilets and Waste Systems, Remote handheld on/off switch with 6' (1.8 m) wire harness. Join the #1 RV Forum Today - It's Totally Free! The fresh water connection is for flushing the macerator after use. connector-cable for a fully portable installation.

Could not find any links for specified country.

#k '(C]?T7r!ovqdG wOW /N I made a cable assembly with a 7-way female plug at one end that I hook up to the trailer's plug. Since the pump is designed to run from 12VDC, you'll need a battery to power it. Maybe my installation was a bit over capacity, but it made me feel safe. Login with username, password and session length.

>> The pump switch has a fuse so i do not think i need to wire another, but i do need to connect to a 12v source.

Turn off water and pump, disconnect hose and, 1. For my poop-pump, I just spliced on a 15' run of 10AWG dual conductor cable with alligator clamps on the end.

Inside of that box there are about 6 or 8 screws (perhaps terminals). Turn off pump, open rinsing valve and back fill, tanks for rinsing. Do you need advice on what products to buy? Ran the shipped wire harness to a take off point near the front where all the 12V wires go.straight into the batteries. Fuse Replacement: The fuse is located under the, black dust cover on the bottom of the On/Off Control, Handle. No. This is an independent, unofficial site. The unit uses a 20 amp fuse, the regular 12 volt convinence outlet in the camper is not up to that kind of load, you stand a real good chance of damage if you try that. Not many RV's have an electrical circuit nearby that can be hi-jacked to run the sizeable electrical load of the pump. Re: How and where to wire Flojet Macerator, Quote from: ForestCreature on March 10, 2011, 05:40:57 am, Quote from: Chuck S on March 10, 2011, 07:09:31 am, Topic: How and where to wire Flojet Macerator (Read 13376 times). Please check back later.

I wasn't aware that jump boxes supplied a continuous current. 4 0 obj

I think most of those who commit the 12awg is too small need to google open air current rating of wire. GW, Gary is right on all accounts.

Fuses are rated for wiring protection, not for the load.

Listen to what FishingHat has to say as he's right on track. Make DARN SURE that pump has all the current it needs to do its job. Much easier without the previous ordeal with jumper cables run to the onboard battery in the front compartment. When I get around to it I will go for a direct run (fused)to the battery. Keep me on the current site. Is the wiring one section or multi section.

I added a new circuit in my converter fuse box for the pump. PumpsandPartsShippedFast! Since I'm not much of a plumber, but a darn good electrician, I'd rather run wiring than plumbing. I ended up simply adding alligator clips to the flojet wires and clipping to the battery. Go RVing In Virginia: Bethpage Camp-Resort & G How To Stay Cool In Your RV This Fourth Of July, Visit Sun Retreats Cape May In New Jersey. max.)

I had a spare circuit on my 12v panel which I wired into with the provided Flojet wire with a 20 Amp fuse. I can lug that charging box around as the flo-jet power source. iRV2.com RV Community - Are you about to start a new improvement on your RV or need some help with some maintenance? Many times it requires running new wiring. I used 10ga wire, the "pump" is fused already. hVN1 Z/(CTK-Q!AIsvsYH6*r5*lRW&Y|ReEdmUyUTz\csYNFl:nf|t:Wx2|muY7E>?,<43xyfrqAKY?m[!r*b|M3Q@YLe 5wF';JONe_ris]?s&p5m$$2UBa|) |W(Q%= :Jty];v4fbPL =`nN]^~]\_>/;])iRC}?_{Gp1I_H sHMP*\[ Check the post and photos I place this morning under camper modifications. Copyright 2022 Xylem. Let gray. Best of all it's totally FREE! Contact Us. Hi.

Yes, please. Refer to electrical drawing above. Heat Exhaustion Symptoms To Look Out For While RVi How To Find Seasonal Jobs For Full Time RVers, 10 Best Bozeman RV Parks & Campgrounds, Plan Your Yellowstone Trip With This Helpful Tool. Includes 2 Gaskets, Nitrile Impeller, Small Wear Plate, Body With Discharge Port, Lip Seal.

54 0 obj <> endobj 67 0 obj <>/Filter/FlateDecode/ID[<97F72DA6B76D4CECB8E3E4AC55CDC07F>]/Index[54 34]/Info 53 0 R/Length 72/Prev 260921/Root 55 0 R/Size 88/Type/XRef/W[1 2 1]>>stream stream Changing the fuse to a 20A doesn't change the capacity of the wiring - you run the risk of melting insulation or even burning out a wire with the Flojet.

[]`FbrM|Gc@Z T7U[)d*:0x*Ztev`|~Kl^,M+SH3;IIil'Fe^}{Su10wfHe g[?k~u9y K8k{gHf3g`Yg.A/ This is probably true only for the plumbing portion. 3. Thanks, Mike. I too have installed this pump.

The Fiber Washers Are No Longer Used. /Length 278969 I just bought a flo jet, and 40 feet of 1" macerator hose. You must log in or register to reply here. water backflush black water tank.

Some mac's can require beaucoup power.

When I use the pump, I just clamp it directly onto the battery.

quote:

Originally posted by GLWilliams58: Enjoy San Diego!

The Flojet 18555-000 DC portable waste pump is the ideal solution for emptying holding tanks on recreational vehicles and avoiding dump stations. A forum community dedicated to Keystone Outbacker RV owners and enthusiasts. Could not complete your request right now.

We use a macerator as well, have been (dumped full load last weekend) using a jump box for the 12V and pumping through a 100' garden hose. Any help would be appreciated.

<>] I think you found the trailer light wiring box How did you get those wires down through the belley? We have many shipping options available. 6. According to the data sheet, it apparently comes with a fused switch and all wiring necessary to connect it to a 20A source of power from the battery.

)iLr&xZR6&JERIJ^L|dg1)HcCHA#^,6z 9c},@8_y$53:F.#sY%~8\U*!b=!X?rJ~vxdU"FsK.-4fG#v!prUGwqWEKO`fzqHR1Q]dXo~Vm"*G,8rbT{9*% nq:(&ueSz%N9iI`': )R6u+Ce%G. For a better experience, please enable JavaScript in your browser before proceeding.

Is there a certain amp or peak power that it should be? I don't have a battery, and if I bought one, the battery terminals are on the opposite side of the camper (about 30ft). Works great. I have no wiring experience at all. Mine wasn't using the third hole. self-priming macerator, 2.

No matter where you fit in you'll find that iRV2 is a great community to join. %PDF-1.6 % That way no wires to corrode or accidentally fray and short. I have electricty but no water or sewer hookup.

For safety's sake, I installed a 30 amp fuse on 10 gauge wire to the macerator I had in my boat.

Quick question, do you always need a water source going into the 3/4 fw hose connection? 8 Best San Diego RV Parks And Res RV Parks & Campgrounds in Orlando, Florida, What Is A DC To DC Charger And Why You Need One. Close both drain valves, turn on rinse water (40 PSI. That's how I have mine. Some connect to wiring under the trailer - I copied Oz and Us and made a cord with a Bargman end that uses the battery for power.

hV[W8+z}`lY>sn8;

JavaScript is disabled. I have been reading a lot of the messages on the flojet. You are currently viewing our boards as a guest so you have limited access to our community. Here is a pic of the numbers I ran for 20 feet of wire to the converter. For now (Winter), I just routed the wire through the outlet for my 30 Amp cord, which is very close the the BW and GW drain where the Flojet will attach. I wish the pump came wired up with a regular plug or adapter to plug into the regular plug inside of the camper. The reason for this is that I didn't want to mess with a long run of cable from the Bargman.

%SBR8-F 4R[h:JD ]h%,}E:VPV5B7o\~H sr#[.Eb6!-#tH%sEgf!DE6MzkLzw!Z6r~v{*W\}%d:-0~]?\UBY8l4n`Pe=}[8wp. >

I would rather dump into one of the totes and take the tote to state campground instead of packing up and moving the trailer. my sewer hookup was in a compartment next to my generator and I just tapped onto the two leads there.

) n`c P*|Gq=#W\ COG|i,Ft*[~ Made my own extension line out of 10 GA marine grade wire and 20 amp fuse.

The macerator section grinds waste down to a particle size of 1/8" maximum so it can easily be pumped through a garden hose (5/8" minimum). b2FVYn Be sure receptical is rated at 20 amps,many autostore/Radio Shack aftermarkets are not. Your request has been received, and a Xylem expert will be in touch with you soon.

I just bought some 10 gauge automotive stranded wire and some battery clamps and made a nice extension that is pretty simple to use and store. Please take the time to register and you will gain a lot of great new features including; the ability to participate in discussions, network with other RV owners, see fewer ads, upload photographs, create an RV blog, send private messages and so much, much more!

I have a FloJet, a 12vdc air compressor and a 12vdc impact wrench, so I need 12vdc near the tires on both sides of the trailer and truck and near the sewer connections on the trailer. Whether you would like additional information or are interested in getting a quote, we're here to help.

If I get a poop cannon, I was planning on tapping into the wiring for the slide motor. I'll second the Bargman set up. Turn on pump. Be sure that o-ring is on pump adapter prior to, 3. I tapped into the main 12V line under the trailer and have the connection at the dump valve, similar to what Chuck did. I recently purchased a flojet macerator pump. We use cookies to improve your experience on this website and so that ads you see online can be tailored to your online browsing interests. Putting a couple of wires thru it compromises it in no way. Near the outback21rs batteries there is a box on the frame which state Battery hookup - (+) black (-) white and on the cover is the words bargman. For my pump, I just use my jump box that I carry around in the truck. %

Turn off rinse, 8.

two of these are white and black respectively, the others are colored. Steel Valve Stems For Pressure Pro System, Currently Active Users Viewing This Thread: 1. 7. 4. Twenty amps requires 12 gauge wire. I never had any problems and it worked just fine.

This spring, I want to put a switch inline so I can shut off the PC from the front of the trailer when I am pumping into a tote in the back of my truck. My floor is insulated.

This website is not affiliated with or endorsed by Forest River, Inc. or any of its affiliates.

I use it for both my air pump and the macerator.

Wires fell off a few times, I need better clips but got the job done. I wanted 12V power by the sewer outlet for it and this is what I came up with: I was lucky. This Kit No Longer Includes The 2 Short Studs Or The Fiber Washers. Install portable waste pump on drain in any. endstream endobj 85 0 obj <>stream It's a long story but I ended up with a NIB 12V macerator pump off Craigslist. I suppose eventually I will get around to running a wire for my Flo-Jet but until then I just use my jump start battery pack. %PDF-1.6 % 2014 Flagstaff Super Lite 27RLWS Emerald Ed. hSj0I=,>aJs(G[TziR8( $,a`gAX";_qi8=@0[Vu^+6n&w.ke-@'[Qf c4exU7z(-e/w Af t,o..<7*[s?9 CGj# How To Road Trip Like A Pro With Hipcamp And RV LI Lake Superior Campsites With Great Reviews, Powered by vBulletin Version 3.8.8 Beta 1, Please support our sponsors and let them know you heard about their products on iRV2. XI.9ry13 4AKA4R/t}gV@P$t:G8c1j uZz^m\=71su,{`9{f'V[]mlT.7_X`<66jXS-|zs\-'O[l4ZsR5y>%E:cFN"pE@I"4ki6{{rY{{;/5s/L`LYW[ZKJ|u=uXB[42|-BTZs)7F_CYEgmMdW_Z+gxlHByHC&hB^

• Honeywell Heaters For Sale
• Bronx And Banco Megan Dress
• Hotel California Palm Springs For Sale
• Toyota Tundra Suspension Lift Kits
• Marshalls Plus Size Dresses
• Now Liver Refresh Ingredients
• Linon Kitchen Cart Assembly Instructions
• Blackstar Carry-on Travel Guitar Size
• White South Sea Pearl Earrings
• Magnolia Salt And Pepper Shakers
• 2018 Nissan Pathfinder Sunshade
• @okta/okta-signin-widget Npm
• Magnetic Name Tags For Whiteboard
• Ruby And Diamond Heart Pendant
• 2 Hdpe Water Pipe Roll 1000'
• Tozey Patio Furniture
• Laura Mercier Travel Brush Set

Sitemap 66